Similar articles

Abstract: Lower-limb assisted exoskeletons are widely researched for movement assistance or rehabilitation training. Due to advantages of compliance with human body and lightweight, some cable-driven prototypes have been developed, but most of these can assist only unidirectional movement. In this paper we present an untethered cable-driven ankle exoskeleton that can achieve plantarflexion-dorsiflexion bidirectional motion bilaterally using a pair of single motors. The main weights of the exoskeleton, i.e., the motors, power supplement units, and control units, were placed close to the proximity of the human body, i.e., the waist, to reduce the redundant rotation inertia which would apply on the wearer’s leg. A cable force transmission system based on gear-pulley assemblies was designed to transfer the power from the motor to the end-effector effectively. A cable self-tension device on the power output unit was designed to tension the cable during walking. The gait detection system based on a foot pressure sensor and an inertial measurement unit (IMU) could identify the gait cycle and gait states efficiently. To validate the power output performance of the exoskeleton, a torque tracking experiment was conducted. When the subject was wearing the exoskeleton with power on, the muscle activity of the soleus was reduced by 5.2% compared to the state without wearing the exoskeleton. This preliminarily verifies the positive assistance effect of our exoskeleton. The study in this paper demonstrates the promising application of a lightweight cable-driven exoskeleton on human motion augmentation or rehabilitation.

可实现跖屈–背屈双向运动辅助的绳驱动踝关节外骨骼

[1]Asbeck AT, de Rossi SMM, Galiana I, et al., 2014. Stronger, smarter, softer: next-generation wearable robots. IEEE Robot Autom Mag, 21(4):22-33.

[2]Awad LN, Bae J, O’donnell K, et al., 2017. A soft robotic exosuit improves walking in patients after stroke. Sci Trans Med, 9(400):eaai9084.

[3]Bai Y, Gao XS, Zhao J, et al., 2015. A portable ankle-foot rehabilitation orthosis powered by electric motor. Open Mech Eng J, 9(1):982-991.

[4]Browning RC, Modica JR, Kram R, et al., 2007. The effects of adding mass to the legs on the energetics and biomechanics of walking. Med Sci Sports Exerc, 39(3):515-525.

[5]Cherry MS, Kota S, Young A, et al., 2016. Running with an elastic lower limb exoskeleton. J Appl Biomech, 32(3): 269-277.

[6]Collins SH, Wiggin MB, Sawicki GS, 2015. Reducing the energy cost of human walking using an unpowered exoskeleton. Nature, 522(7555):212-215.

[7]Diller S, Majidi C, Collins SH, 2016. A lightweight, low- power electroadhesive clutch and spring for exoskeleton actuation. Proc IEEE Int Conf on Robotics and Automation, p.682-689.

[8]Dong TY, Zhang XL, Liu T, 2018. Artificial muscles for wearable assistance and rehabilitation. Front Inform Technol Electron Eng, 19(11):1303-1315.

[9]Farris RJ, Quintero HA, Goldfarb M, 2011. Preliminary evaluation of a powered lower limb orthosis to aid walking in paraplegic individuals. IEEE Trans Neur Syst Rehabil Eng, 19(6):652-659.

[10]Forrester LW, Roy A, Krebs HI, et al., 2011. Ankle training with a robotic device improves hemiparetic gait after a stroke. Neurorehabil Neur Repair, 25(4):369-377.

[11]Galle S, Malcolm P, Collins SH, et al., 2017. Reducing the metabolic cost of walking with an ankle exoskeleton: interaction between actuation timing and power. J Neuroeng Rehabil, 14(1):35.

[12]He Y, Li N, Wang C, et al., 2019. Development of a novel autonomous lower extremity exoskeleton robot for walking assistance. Front Inform Technol Electron Eng, 20(3):318-329.

[13]Hou TG, Yang XB, Aiyama Y, et al., 2019. Design and experiment of a universal two-fingered hand with soft fingertips based on jamming effect. Mech Mach Theory, 133:706-719.

[14]Jatsun S, Savin S, Yatsun A, 2017. Footstep planner algorithm for a lower limb exoskeleton climbing stairs. Proc 2^nd Int Conf on Interactive Collaborative Robotics, p.75-82.

[15]Jiménez-Fabián R, Verlinden O, 2012. Review of control algorithms for robotic ankle systems in lower-limb orthoses, prostheses, and exoskeletons. Med Eng Phys, 34(4):397-408.

[16]Kim S, Son Y, Choi S, et al., 2015. Design of a simple, lightweight, passive-elastic ankle exoskeleton supporting ankle joint stiffness. Rev Sci Instrum, 86(9):095107.

[17]Kuan JY, Pasch KA, Herr HM, 2018. A high-performance cable-drive module for the development of wearable devices. IEEE/ASME Trans Mech, 23(3):1238-1248.

[18]Kumar BP, Krishnan CMC, 2016. Comparative study of different control algorithms on brushless DC motors. Proc Biennial Int Conf on Power and Energy Systems: Towards Sustainable Energy, p.1-5.

[19]Kyeong S, Shin W, Yang MJ, et al., 2019. Recognition of walking environments and gait period by surface electromyography. Front Inform Technol Electron Eng, 20(3): 342-352.

[20]Lairamore C, Garrison MK, Bandy W, et al., 2011. Comparison of tibialis anterior muscle electromyography, ankle angle, and velocity when individuals post stroke walk with different orthoses. Prosthet Orthot Int, 35(4):402- 410.

[21]Lin PY, Yang YR, Cheng SJ, et al., 2006. The relation between ankle impairments and gait velocity and symmetry in people with stroke. Arch Phys Med Rehabil, 87(4):562- 568.

[22]Mancini M, Chiari L, Holmstrom L, et al., 2016. Validity and reliability of an IMU-based method to detect APAs prior to gait initiation. Gait Post, 43:125-131.

[23]Meijneke C, van Dijk W, van der Kooij H, 2014. Achilles: an autonomous lightweight ankle exoskeleton to provide push-off power. Proc 5^th IEEE RAS/EMBS Int Conf on Biomedical Robotics and Biomechatronics, p.918-923.

[24]Miller LE, Zimmermann AK, Herbert WG, 2016. Clinical effectiveness and safety of powered exoskeleton-assisted walking in patients with spinal cord injury: systematic review with meta-analysis. Med Dev Evid Res, 9:455-466.

[25]Morris M, Shoham M, 2009. Applications and theoretical issues of cable-driven robots. Proc Florida Conf on Recent Advances in Robotics, p.1-29.

[26]Noda T, Takai A, Teramae T, et al., 2018. Robotizing double- bar ankle-foot orthosis. Proc IEEE Int Conf on Robotics and Automation, p.2782-2787.

[27]Novacheck TF, 1998. The biomechanics of running. Gait Post, 7(1):77-95.

[28]Park YL, Chen BR, Pérez-Arancibia NO, et al., 2014. Design and control of a bio-inspired soft wearable robotic device for ankle–foot rehabilitation. Bioinspir Biomim, 9(1): 016007.

[29]Ruiz AF, Forner-Cordero A, Rocon E, et al., 2006. Exoskeletons for rehabilitation and motor control. Proc 1^st IEEE/RAS-EMBS Int Conf on Biomedical Robotics and Biomechatronics, p.601-606.

[30]Rupal BS, Singla A, Virk GS, 2016. Lower limb exoskeletons: a brief review. Proc 22^nd National Conf on Mechanical Engineering and Technology, p.130-140.

[31]Sankai Y, 2010. HAL: hybrid assistive limb based on cybernics. In: Kaneko M, Nakamura Y (Eds.), Robotics Research. Springer Berlin Heidelberg, p.25-34.

[32]Sawicki GS, Khan NS, 2016. A simple model to estimate plantarflexor muscle–tendon mechanics and energetics during walking with elastic ankle exoskeletons. IEEE Trans Biomed Eng, 63(5):914-923.

[33]Shorter KA, Kogler GF, Loth E, et al., 2011. A portable powered ankle-foot orthosis for rehabilitation. J Rehabil Res Dev, 48(4):459-472.

[34]Stewart JD, 2008. Foot drop: where, why and what to do? Pract Neurol, 8(3):158-169.

[35]Taborri J, Palermo E, Rossi S, et al., 2016. Gait partitioning methods: a systematic review. Sensors, 16(1):66.

[36]Wehner M, Quinlivan B, Aubin PM, et al., 2013. A lightweight soft exosuit for gait assistance. Proc IEEE Int Conf on Robotics and Automation, p.3362-3369.

[37]Winter DA, 2009. Biomechanics and Motor Control of Human Movement. Wiley, Hoboken, USA.

[38]Witte KA, Zhang JJ, Jackson RW, et al., 2015. Design of two lightweight, high-bandwidth torque-controlled ankle exoskeletons. IEEE Int Conf on Robotics and Automation, p.1223-1228.

[39]Wu A, Yang XB, Kuan JY, et al., 2019. An autonomous exoskeleton for ankle plantarflexion assistance. Int Conf on Robotics and Automation, p.1713-1719.

[40]Zhang YF, Kleinmann RJ, Nolan KJ, et al., 2019. Preliminary validation of a cable-driven powered ankle–foot orthosis with dual actuation mode. IEEE Trans Med Robot Bion, 1(1):30-37.

[41]Zoss A, Kazerooni H, Chu A, 2005. On the mechanical design of the Berkeley Lower Extremity Exoskeleton (BLEEX). IEEE/RSJ Int Conf on Intelligent Robots and Systems, p.3465-3472.