Similar articles

Abstract: Reinforced concrete (RC) slabs are the primary load-carrying member of underwater facilities. They can suffer severe local failures such as cratering, spalling, or breaching as a result of underwater close-in (UWCI) explosions. In this study, we established a fully validated high-fidelity finite element analysis approach to precisely reproduce the local failures of RC slabs after a UWCI explosion. A recently proposed dynamic constitutive model is used to describe wet concrete. The effects of free water content on the material properties, including the tensile/compressive strength, elastic modulus, strain rate effect, failure strength surface, and equation of state, are comprehensively calibrated based on existing test data. The calibrated material parameters are then verified by a single-element test. A high-fidelity finite element analysis (FEA) approach of an RC slab subjected to a UWCI explosion is established using an arbitrary Lagrangian-Eulerian (ALE) algorithm. Simulating previous UWCI explosion tests on RC orifice targets and underwater contact explosion tests on saturated concrete slabs showed that the established FEA approach could accurately reproduce the pressure-time history in water and damage patterns, including the cracking, cratering, and spalling, of the RC orifice target and saturated concrete slab. Furthermore, parametric studies conducted by simulating an RC slab subjected to a UWCI explosion showed that: (i) the local failure of an RC slab enlarges with increased charge weight, reduced standoff distance, and reduced structural thickness; (ii) compared to a water-backed RC slab, an air-backed RC slab exhibits much more obvious local and structural failure. Lastly, to aid the anti-explosion design of relevant underwater facilities, based on over 90 simulation cases empirical formulae are summarized to predict local failure modes, i.‍e., no spall, spall, and breach, of water- and air-backed RC slabs subjected to a UWCI explosion.

水中近场爆炸下钢筋混凝土板局部破坏模式数值模拟研究

[1]AttardMM, SetungeS, 1996. Stress-strain relationship of confined and unconfined concrete. ACI Materials Journal, 93(5):432-442.

[2]ChenZJ, ZongZH, GanL, et al., 2023. Numerical investigation on dynamic response of air-backed RC slabs subjected to close-in underwater explosion. Ocean Engineering, 273:113962.

[3]ColeRH, 1948. Underwater Explosions. Princeton University Press, New Jersey, USA.

[4]Comite Euro-International Du Beton, 1993. CEB-FIP Model Code 1990: Design Code. London, UK.

[5]CostanzoFA, 2011. Underwater explosion phenomena and shock physics. In: Proulx T (Ed.), Structural Dynamics, Volume 3. Conference Proceedings of the Society for Experimental Mechanics Series. Springer, New York, USA.

[6]ForquinP, SallierL, PontiroliC, 2015. A numerical study on the influence of free water content on the ballistic performances of plain concrete targets. Mechanics of Materials, 89:176-189.

[7]HallquistJ, 2006. LS-DYNA Theory Manual. Livermore Software Technology Corporation, Livermore, California, USA.

[8]HuJ, ChenZY, ZhangXD, et al., 2017. Underwater explosion in centrifuge part I: validation and calibration of scaling laws. Science China Technological Sciences, 60(11):1638-1657.

[9]HuangXP, HuJ, ZhangXD, et al., 2020. Bending failure of a concrete gravity dam subjected to underwater explosion. Journal of Zhejiang University-SCIENCE A (Applied Physics & Engineering), 21(12):976-991.

[10]KlepaczkoJR, BraraA, 2001. An experimental method for dynamic tensile testing of concrete by spalling. International Journal of Impact Engineering, 25(4):387-409.

[11]KongXZ, FangQ, ChenL, et al., 2018. A new material model for concrete subjected to intense dynamic loadings. International Journal of Impact Engineering, 120:60-78.

[12]KumarV, KartikKV, IqbalMA, 2020. Experimental and numerical investigation of reinforced concrete slabs under blast loading. Engineering Structures, 206:110125.

[13]LiHD, LiYB, PanYF, et al., 2023. Compressive properties of a novel slurry-infiltrated fiber concrete reinforced with arc-shaped steel fibers. Journal of Zhejiang University-SCIENCE A (Applied Physics & Engineering), 24(6):543-556.

[14]MagnusD, KhanMA, ProudWG, 2018. Epidemiology of civilian blast injuries inflicted by terrorist bombings from 1970‒2016. Defence Technology, 14(5):469-476.

[15]MalecotY, ZinggL, BriffautM, et al., 2019. Influence of free water on concrete triaxial behavior: the effect of porosity. Cement and Concrete Research, 120:207-216.

[16]MalvarLJ, CrawfordJE, WesevichJW, et al., 1997. A plasticity concrete material model for DYNA3D. International Journal of Impact Engineering, 19(9-10):847-873.

[17]McVayMK, 1988. Spall Damage of Concrete Structures. Technical Report SL-88-22, US Army Corps of Engineers, Waterways Experiment Station, Vicksburg, USA.

[18]Nord Stream Press Releases, 2022. Incident on the Nord Stream Pipeline, 2022-11-14. https://www.nord-stream.com/press-info/press-releases/

[19]RajendranR, LeeJM, 2009. Blast loaded plates. Marine Structures, 22(2):99-127.

[20]RossCA, JeromeDM, TedescoJW, et al., 1996. Moisture and strain rate effects on concrete strength. ACI Materials Journal, 93(3):293-300.

[21]SandersJ, UrgessaG, LöhnerR, 2021. Literature review on the response of concrete structures subjected to underwater explosions. CivilEng, 2(4):895-908.

[22]ShiYC, ChenL, WangZQ, et al., 2015. Field tests on spalling damage of reinforced concrete slabs under close-in explosions. International Journal of Protective Structures, 6(2):389-401.

[23]ShiYC, WangJ, CuiJ, 2020. Experimental studies on fragments of reinforced concrete slabs under close-in explosions. International Journal of Impact Engineering, 144:103630.

[24]Southpointe, 2020. ANSYS Explicit Dynamics Analysis Guide. ANSYS, Inc, Canonsberg, USA.

[25]TuZG, LuY, 2009. Evaluation of typical concrete material models used in hydrocodes for high dynamic response simulations. International Journal of Impact Engineering, 36(1):132-146.

[26](Unified Facilities Criteria)UFC, 2008. UFC 3-340-02 Structures to Resist the Effects of Accidental Explosions, with Change 2. UFC, Department of Defense, USA. https://wbdg.‍org/ffc/dod/unified-facilities-criteria-ufc/ufc-3-340-02

[27]WangH, WangLC, SongYP, et al., 2016. Influence of free water on dynamic behavior of dam concrete under biaxial compression. Construction and Building Materials, 112:222-231.

[28]WangW, ZhangD, LuFY, et al., 2012. Experimental study on scaling the explosion resistance of a one-way square reinforced concrete slab under a close-in blast loading. International Journal of Impact Engineering, 49:158-164.

[29]WenYB, ChiH, LaiZC, et al., 2023. Experimental and numerical investigation on saturated concrete subjected to underwater contact explosion. Construction and Building Materials, 384:131465.

[30]WuSX, ChenXD, ZhouJK, 2012. Influence of strain rate and water content on mechanical behavior of dam concrete. Construction and Building Materials, 36:448-457.

[31]XuH, WenHM, 2013. Semi-empirical equations for the dynamic strength enhancement of concrete-like materials. International Journal of Impact Engineering, 60:76-81.

[32]XuSL, WuP, ZhouF, et al., 2020. A dynamic constitutive model of ultra high toughness cementitious composites. Journal of Zhejiang University-SCIENCE A (Applied Physics & Engineering), 21(12):939-960.

[33]YangGD, WangGH, LuWB, et al., 2019. Experimental and numerical study of damage characteristics of RC slabs subjected to air and underwater contact explosions. Marine Structures, 66:242-257.

[34]YangGD, FanY, WangGH, et al., 2022. Blast resistance of air-backed RC slab against underwater contact explosion. Defence Technology, 28:236-250.

[35]YangGD, FanY, WangGH, et al., 2023a. Experimental and numerical investigation on dynamic behavior of RC orifice targets subjected to underwater explosions. Engineering Structures, 279:115541.

[36]YangGD, FanY, WangGH, et al., 2023b. Mitigation effects of air-backed RC slabs retrofitted with CFRP subjected to underwater contact explosions. Ocean Engineering, 267:113261.

[37]ZhaoFQ, WenHM, 2018. Effect of free water content on the penetration of concrete. International Journal of Impact Engineering, 121:180-190.

[38]ZhaoXH, WangGH, LuWB, et al., 2018. Damage features of RC slabs subjected to air and underwater contact explosions. Ocean Engineering, 147:531-545.

[39]ZhaoXH, WangGH, LuWB, et al., 2021. Experimental investigation of RC slabs under air and underwater contact explosions. European Journal of Environmental and Civil Engineering, 25(1):190-204.

[40]ZhouF, ChengYH, PengQ, et al., 2023a. Influence of steel reinforcement on the performance of an RC structure subjected to a high-velocity large-caliber projectile. Structures, 54:716-731.

[41]ZhouF, SuQ, ChengYH, et al., 2023b. Novel constitutive model of UHPC under impact and blast loadings considering compaction of shear dilation. International Journal of Impact Engineering, 173:104468.

[42]ZhouF, SuQ, ChengYH, et al., 2023c. A novel dynamic constitutive model for UHPC under projectile impact. Engineering Structures, 280:115711.

[43]ZhouF, WuH, ChengYH, 2023d. Perforation studies of concrete panel under high velocity projectile impact based on an improved dynamic constitutive model. Defence Technology, 27:64-82.