Abstract: Soil backfilling and compaction are often involved in urban construction projects like the burying of power cables. The thermal conductance of backfill soil is therefore of great interest. To investigate the thermal conductivity variation of compacted backfill soil, 10 typical soils sampled in Zhejiang Province of China with moisture contents of 0%–25% were fully compacted according to the Proctor compaction test method and then subjected to thermal conductivity measurement using the thermal probe method at 20 °C. The particle size distribution and the chemical composition of the soil samples were characterized to analyze their effects on thermal conductivity. The results showed that the maximum thermal conductivity of fully compacted soils generally exceeds 1.9 W/(m·K) and is 20%–50% higher than that of uncompacted soils. With increasing moisture content, soil thermal conductivity and dry bulk density first increase and then remain unchanged or decrease slowly; the critical moisture content is greater than 20% in most cases. Overall, the critical moisture content of soils with large particle size is lower than that of those with small particle size. Quartz has the highest thermal conductivity in the soil solid phase, and the mass percentage of quartz for most soils in this study is more than 50%, while that for yellow soil is less than 30%, which leads to the thermal conductivity of the former being nearly twice as great as that of the latter in most circumstances. Based on regression analysis, with moisture content and dry bulk density as the independent parameters, the prediction formulae for the thermal conductivity of two categories of compacted backfill soils are proposed for practical applications.

含水率和干容积密度对压实回填土热导率的影响

[1]Abu-HamdehNH, ReederRC, 2000. Soil thermal conductivity effects of density, moisture, salt concentration, and organic matter. Soil Science Society of America Journal, 64(4):1285-1290.

[2]Abu-HamdehNH, KhdairAI, ReederRC, 2001. A comparison of two methods used to evaluate thermal conductivity for some soils. International Journal of Heat and Mass Transfer, 44(5):1073-1078.

[3]AlzabeebeeS, 2020. Influence of backfill soil saturation on the structural response of buried pipes. Transportation Infrastructure Geotechnology, 7(2):156-174.

[4]CampbellGS, 1986. Soil physics with basic. Soil Science, 142(6):367-368.

[5]ChungSO, HortonR, 1987. Soil heat and water flow with a partial surface mulch. Water Resources Research, 23(12):2175-2186.

[6]CôtéJ, KonradJM, 2005. A generalized thermal conductivity model for soils and construction materials. Canadian Geotechnical Journal, 42(2):443-458.

[7]CzappS, RatkowskiF, 2021. Optimization of thermal backfill configurations for desired high-voltage power cables ampacity. Energies, 14(5):1452.

[8]DDI (Decagon Devices, Inc.), 2016. KD2 Pro Thermal Properties Analyzer: Operator’s Manual. http://library.metergroup.com/Manuals/13351_KD2%20Pro_Web.pdf

[9]de Lieto VollaroR, FontanaL, VallatiA, 2014. Experimental study of thermal field deriving from an underground electrical power cable buried in non-homogeneous soils. Applied Thermal Engineering, 62(2):390-397.

[10]DuanY, 2015. Experimental Study on Testing and Variation of Soil Thermophysical Parameters. MS Thesis, Taiyuan University of Technology, Taiyuan, China(in Chinese).

[11]GemantA, 1950. The thermal conductivity of soils. Journal of Applied Physics, 21(8):750-752.

[12]HanZ, VanapalliSK, RenJP, et al., 2018. Characterizing cyclic and static moduli and strength of compacted pavement subgrade soils considering moisture variation. Soils and Foundations, 58(5):1187-1199.

[13]HeHL, HeD, JinJM, et al., 2020. Room for improvement: a review and evaluation of 24 soil thermal conductivity parameterization schemes commonly used in land-surface, hydrological, and soil-vegetation-atmosphere transfer models. Earth-Science Reviews, 211:103419.

[14]HiraiwaY, KasubuchiT, 2000. Temperature dependence of thermal conductivity of soil over a wide range of temperature (5–75 °C). European Journal of Soil Science, 51(2):211-218.

[15]HuangCY, XuJM, 2010. Soil Science, 3rd Edition. China Agricultural Press, Beijing, China, p.1-379 (in Chinese).

[16](International Electrotechnical Commission)IEC, 2006. Electric Cables–Calculation of the Current Rating–Part 1-1: Current Rating Equations (100% Load Factor) and Calculation of Losses–General, IEC 60287-1-1:2006. IEC, Geneva, Switzerland.

[17]JohansenO, 1975. Thermal Conductivity of Soils. PhD Thesis, Norwegian University of Science and Technology, Trondheim, Norway.

[18]KimYS, KimJH, ChoDS, 2014. Implementation of optimized backfill materials for underground electric power cables. Journal of Porous Media, 17(9):831-840.

[19]KongDQ, WanR, ChenJX, et al., 2020. Effect of gradation on the thermal conductivities of backfill materials of ground source heat pump based on loess and iron tailings. Applied Thermal Engineering, 180:115814.

[20]LeTHM, LeeTW, SeoJW, et al., 2021. Experimental investigation and numerical analysis on the performance of flowable soil as feasible backfill material for railway bridge approach. Transportation Geotechnics, 28:100542.

[21]LeungMKH, ChanKY, 2009. Theoretical and experimental studies of heat transfer with moving phase-change interface in freezing and thawing of porous potting soil. Journal of Zhejiang University-SCIENCE A, 10(1):1-6.

[22]LuJ, HuangZZ, HanXF, 2005a. Water and heat transport in hilly red soil of southern China: I. Experiment and analysis. Journal of Zhejiang University-SCIENCE B, 6(5):331-337.

[23]LuJ, HuangZZ, HanXF, 2005b. Water and heat transport in hilly red soil of southern China: II. Modeling and simulation. Journal of Zhejiang University-SCIENCE B, 6(5):338-345.

[24]LuS, RenTS, GongYS, et al., 2007. An improved model for predicting soil thermal conductivity from water content at room temperature. Soil Science Society of America Journal, 71(1):8-14.

[25]MaGZ, WeiHL, FuCB, 2000. Relationship between regional soil moisture variation and climatic variability over East China. Acta Meteorologica Sinica, 58(3):278-287 (in Chinese).

[26]MenaceurH, CuisinierO, MasrouriF, et al., 2021. Impact of monotonic and cyclic suction variations on the thermal properties of a stabilized compacted silty soil. Transportation Geotechnics, 28:100515.

[27]MengistuAG, van RensburgLD, MavimbelaSSW, 2017. The effect of soil water and temperature on thermal properties of two soils developed from Aeolian sands in South Africa. CATENA, 158:184-193.

[28]MinJ, 2021. Research on Influencing Factors of Performance of Underground Heat Exchanger of Ground Source Heat Pump. MS Thesis, Anhui Jianzhu University, Hefei, China(in Chinese).

[29]MOHURD (Ministry of Housing and Urban-Rural Development of the People’s Republic of China), 2018. Standard for Design of Cables of Electric Power Engineering, GB 50217-2018. National Standards of the People’s Republic of China(in Chinese).

[30]MOHURD (Ministry of Housing and Urban-Rural Development of the People’s Republic of China), 2019. Standard for Geotechnical Testing Method, GB/T 50123-2019. National Standards of the People’s Republic of China(in Chinese).

[31]NikoosokhanS, NowamoozH, ChazallonC, 2016. Effect of dry density, soil texture and time-spatial variable water content on the soil thermal conductivity. Geomechanics and Geoengineering, 11(2):149-158.

[32]OcłońP, 2021. The effect of soil thermal conductivity and cable ampacity on the thermal performance and material costs of underground transmission line. Energy, 231:120803.

[33]RenXL, YouYH, YuQH, et al., 2021. Determining the thermal conductivity of clay during the freezing process by artificial neural network. Advances in Materials Science and Engineering, 2021:5555565.

[34]RerakM, OcłońP, 2017. The effect of soil and cable backfill thermal conductivity on the temperature distribution in underground cable system. E3S Web of Conferences, 13:02004.

[35]SalataF, NardecchiaF, de Lieto VollaroA, et al., 2015. Underground electric cables a correct evaluation of the soil thermal resistance. Applied Thermal Engineering, 78:268-277.

[36]TangF, LahooriM, NowamoozH, et al., 2021. A numerical study into effects of soil compaction and heat storage on thermal performance of a horizontal ground heat exchanger. Renewable Energy, 172:740-752.

[37]USDA NRCS (United States Department of Agriculture Natural Resources Conservation Service), 2017. Citing Electronic Sources of Information. USDA. https://www.nrcs.usda.gov/wps/portal/nrcs/detail/soils/survey/?cid=nrcs142p2_054167

[38]WallenBM, SmitsKM, SakakiT, et al., 2016. Thermal conductivity of binary sand mixtures evaluated through full water content range. Soil Science Society of America Journal, 80(3):592-603.

[39]WebbJ, 1956. Thermal conductivity of soil. Nature, 177(4517):989.

[40]WuHG, YuJH, ShiCZ, et al., 2021. Pipe-soil interaction and sensitivity study of large-diameter buried steel pipes. KSCE Journal of Civil Engineering, 25(3):793-804.

[41]XiaoHL, WuXJ, ZhouJH, 2007. Study on the calculation of thermal conductivity of rock and soil material. Subgrade Engineering, (3):54-56 (in Chinese).

[42]XuL, YuanHM, JiangRF, et al., 2020. Advances in X-ray diffraction for the determination of clay minerals in soil. Spectroscopy and Spectral Analysis, 40(4):‍1227-1231 (in Chinese).

[43]XuXT, ZhangWD, FanCX, et al., 2020. Effects of temperature, dry density and water content on the thermal conductivity of Genhe silty clay. Results in Physics, 16:102830.

[44]YuWJ, 2017. Methods for Estimation of Mean Annual Soil Temperature in China. MS Thesis, Shenyang Agricultural University, Shenyang, China(in Chinese).

[45]ZhangMY, BiJ, ChenWW, et al., 2018. Evaluation of calculation models for the thermal conductivity of soils. International Communications in Heat and Mass Transfer, 94:14-23.

[46]ZhaoC, DongY, FengYP, et al., 2019. Thermal desorption for remediation of contaminated soil: a review. Chemosphere, 221:841-855.