Similar articles

Abstract: The charging characteristics of the valve-regulated lead acid (VRLA) battery driven by solar energy were experimentally studied through the pressure-control method in this paper. The aims of the research were to increase charging efficiency to make the most of solar energy and to improve charging quality to prolong life of battery. The charging process of a 12 V 12 A·h VRLA battery has been tested under the mode of a stand-alone photovoltaic (PV) system. Results show that the pressure-control method can effectively control PV charging of the VRLA battery and make the best of PV cells through the maximum power point tracking (MPPT). The damage of VRLA battery by excess oxygen accumulation can be avoided through the inner pressure control of VRLA battery. Parameters such as solar radiation intensity, charging power, inner pressure of the battery, and charging current and voltage during the charging process were measured and analyzed.

[1]Fernandez, M., Ruddell, A.J., Vast, N., 2001. Development of a VRLA battery with improved separators and a charge controller for low cost photovoltaic and wind powered installations. Journal of Power Sources, 95(1-2):135-140.

[2]Gao, G., 2008. The analysis and design of a recharging circuit by solar photovoltaic system. Acta Energiae Solaris Sinica, 29(4):404-406 (in Chinese).

[3]Gibson, T.L., Kelly, N.A., 2010. Solar photovoltaic charging of lithium-ion batteries. Journal of Power Sources, 195(12):3928-3932.

[4]Huang, C.H., Huang, C.C., Ou, T.C., Lu, K.H., Hong, C.M., 2009. Intelligent Fuzzy Logic Controller for a Solar Charging System. IEEE/ASME International Conference on Advanced Intelligent Mechatronics, Singapore, p.1412-1417.

[5]Huang, B.J., Hsu, P.C., Wu, M.S., Ho, P.Y., 2010. System dynamic model and charging control of lead-acid battery for stand-alone solar PV system. Solar Energy, 84(5):822-830.

[6]Hussein, A.A.H., Pepper, M., Harb, A., Batarseh, I., 2009. An Efficient Solar Charging Algorithm for Different Battery Chemistries. 5th IEEE Vehicle Power and Propulsion Conference, Dearborn, MI, USA, p.188-193.

[7]Mahmoud, M.M., 2006. Transient analysis of a PV power generator charging a capacitor for measurement of the I-V characteristics. Renewable Energy, 31(13):2198-2206.

[8]Mishra, P.R., Pandey, A.K., Joshi, J.C., 1995. Theoretical analysis of integrated photovoltaic system and design of an optimised battery voltage regulator. Solar Energy Materials and Solar Cells, 37(2):159-174.

[9]Ross, J.N., Markvart, T., 2000. Modeling battery charge regulation for a stand-alone photovoltaic system. Solar Energy, 69(3):181-190.

[10]Singer, S., Rozenshtein, B., Surazi, S., 1984. Characterization of PV array output using a small number of measured parameters. Solar Energy, 32(5):603-607.

[11]Sun, C., Guo, Y., Chen, X., 2009. Research on photovoltaic charger for stand-alone photovoltaic system. Power Electronics, 43(4):44-46 (in Chinese).

[12]Tan, J.J., 2010. Experimental Research and Design of Residential Photovoltaic System. MS Thesis, Zhejiang University, Hangzhou, China (in Chinese).

[13]Xu, J.S., Feng, X.L., Wang, J.Y., 1999. The Pressure- controlled Sealed Battery. Patent No. CN97249861.3, China (in Chinese).

[14]Yamazaki, T., Muramoto, K.I., 1998. An advanced solar charging and battery discharge controller unit. Renewable Energy, 15(1-4):606-609.

[15]Zheng, S.C., Liu, W., Ge, L.S., 2008. Research on solar photovoltaic charging system with TMPPT function. Journal of Electronic Measurement and Instrument, 22(3):11-15 (in Chinese).

[16]Zhou, H.F., Xu, Z.L., Lin, Z.H., 2009. Control Simulation of Charge and Discharge in the Solar Photovoltaic Power Generation System. Symposium on Photonics and Optoelectronics, Wuhan, China, p.1-4 (in Chinese).

[17]Zhu, H., Tan, J.J., Xu, Z.L., 2009. Experimental research on charging characteristics of a pressure-controlled VRLA battery in high-temperature environments. Journal of Zhejiang University-Science A, 10(3):418-422.